Piper PA-44-180 N923RS

Summary

On 24 March 2014 at about 21:38 local time, a Piper PA-44-180 registered N923RS, operated by ATP USA, Inc., was involved in an accident near Brunswick, Georgia, United States. 2 people were on board and 2 died. The aircraft was destroyed. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

24 March 2014 at 21:38

Classification

Accident

Location

Brunswick, Georgia, United States

Coordinates

31.2800, -81.4114

Aircraft

Piper PA-44-180

Registration

N923RS

Category

Airplane

Year built

1979

Engines

2

Operator

ATP USA, Inc.

Operating rule

Part 91: General Aviation

Purpose of flight

Instructional

Phase of flight

Not recorded

Route

Concord → Jacksonville

Aircraft damage

Destroyed

Weather

VMC

Light

Day

NTSB number

ERA14FA168

2 people died.

An inflight failure of the airplane's only operating vacuum pump, which resulted in the loss of attitude information provided by vacuum-driven flight instruments. Also causal was the pilots' failure to maintain control of the airplane while operating in instrument flight rules (IFR) conditions, likely due to spatial disorientation, following the failure of the vacuum pump. Contributing to the accident was the operator's decision to dispatch the airplane with a known inoperative vacuum pump into IFR conditions.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

The pilots of the twin-engine airplane were conducting a cross-country instrument flight rules (IFR) flight. Although both pilots were instrument-rated and IFR-current, the right seat pilot had only 8.8 hours of actual instrument experience, and the left seat pilot had only 1.8 hours of actual instrument experience. While en route and likely operating in IFR conditions, radio and radar contact were lost after the airplane entered a descending, 180-degree right turn. Examination of the wreckage at the accident site revealed signatures consistent with an in-flight breakup of the airframe. The horizontal situation indicator (the only vacuum-system-driven flight instrument that was recovered) exhibited signatures showing that it was likely not operational when the airplane impacted the ground. Both of the engine-driven vacuum pumps exhibited fractured rotors. Although physical examination of the vacuum pumps could not determine whether the rotors fractured before or during impact, the inoperative horizontal situation indicator suggests that both pumps had failed before the impact. The operator reported that the vacuum pump mounted to the airplane's right engine was not operational before the airplane was dispatched on the accident flight and that the pilots had been advised of this deficiency. The operator used the Part 91 minimum equipment limitations for flights, which permitted dispatching the airplane with only one of the two engine-driven vacuum pumps operational. However, the Federal Aviation Administration's master minimum equipment list for the airplane for Part 91 operators, advises operators to limit the airplane to daytime visual flight rules flights when only one of the two vacuum pumps is operational. The operator's decision to dispatch the airplane with a known mechanical deficiency and no operational limitations reduced the safety margin for the flight and directly contributed to the accident. It is likely that the left vacuum pump failed en route rendering the vacuum-driven flight instruments inoperative. Given the pilots' minimal flight experience operating in IFR conditions combined with the difficulty of detecting and responding to the loss of attitude information provided by the vacuum-driven flight instruments, it is likely that the pilots became spatially disoriented and lost control of the airplane, resulting in the subsequent inflight breakup. No definitive determination could be made as to which of the two pilots was acting as pilot-in-command of the airplane at the time of the loss of control.

Quoted verbatim from the NTSB record.