Piper PA-22 N669A

Summary

On 13 May 2024 at about 15:07 local time, a Piper PA-22 registered N669A was involved in an accident near Enderlin, North Dakota, United States. 3 people were on board and 3 had minor injuries. The aircraft was substantially damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

13 May 2024 at 15:07

Classification

Accident

Location

Enderlin, North Dakota, United States

Nearest airport

Enderlin Airport (5N4)

Coordinates

46.6268, -97.6202

Aircraft

Piper PA-22

Registration

N669A

Category

Airplane

Year built

1951

Engines

1

Operator

Not recorded

Operating rule

Part 91: General Aviation

Purpose of flight

Personal

Phase of flight

Not recorded

Aircraft damage

Substantial

Weather

VMC

Light

Day

NTSB number

CEN24LA184

3 people had minor injuries.

The pilot’s failure to properly inspect and sump the fuel system before the flight and the maintenance personnel’s inadequate maintenance of the fuel system which resulted in fuel starvation and the subsequent loss of engine power due to the contamination of the right tank fuel gascolator and fuel lines.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

According to the pilot, shortly after takeoff about 200 ft above ground level (agl), the engine started to run rough. The pilot turned on the carburetor heat and there was a slight improvement in engine performance, but then the engine lost all power. The pilot made an off-airport landing. Upon touchdown, the nosewheel dug into the ground and the airplane flipped inverted. The airplane sustained substantial damage to the left wing, rudder, and engine mount. A postaccident examination of the engine revealed no anomalies that would have precluded normal operation. Examination of the fuel system revealed that the gascolator and bowl for the right tank rear fuel line were full of sediment and debris. Additionally, the fuel lines going to and coming out of the gascolator contained the same deposits that were found in the fuel bowl. The airplane owner said that he assumed the strainer that was under the right front seat was part of the brake system. He was unaware that it was a quick drain gascolator for the right fuel tank and he never sumped that drain. It could not be determined when maintenance personnel last inspected the gascolator. The pilot reported that she flew a total of about 1 hour before the loss of power occurred and had been operating solely on the right fuel tank. Each fuel tank held 18 gallons of fuel and operated independently of each other depending on fuel selector valve selection. Fuel consumption was between 4.5 to 11 gallons per hour, so it is possible there was only about 7 gallons of fuel remaining in the right fuel tank. Although the owner’s handbook cautioned that operating solely on the right fuel tank should only be done if operating in straight and level flight and when the right fuel tank is at 1/3 capacity or lower, the right fuel tank likely contained more than 1/3 its capacity. The sediment and debris clogging the gascolator filter bowl and fuel lines for the right tank’s rear fuel line likely prevented fuel from flowing freely to the engine, which resulted in a loss of engine power due to fuel starvation.

Quoted verbatim from the NTSB record.