Piper PA-30 N30SH

Summary

On 29 October 2021 at about 21:00 local time, a Piper PA-30 registered N30SH was involved in an accident near Waverly, Tennessee, United States. 3 people were on board and nobody was injured. The aircraft was substantially damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

29 October 2021 at 21:00

Classification

Accident

Location

Waverly, Tennessee, United States

Nearest airport

Humphrey's County (0M5)

Coordinates

36.0243, -87.8192

Aircraft

Piper PA-30

Registration

N30SH

Category

Airplane

Year built

1966

Engines

2

Operator

Not recorded

Operating rule

Part 91: General Aviation

Purpose of flight

Personal

Phase of flight

Not recorded

Route

Gallatin → Unknown

Aircraft damage

Substantial

Weather

IMC

Light

Day

NTSB number

ERA22LA037

Nobody was injured.

The pilot’s improper pre-flight fuel planning, which resulted in a total loss of engine power to both engines due to fuel exhaustion.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

The pilot departed on a cross-county flight in his twin-engine airplane and set the fuel selector to the auxiliary tanks. About 7-10 minutes into the flight, the auxiliary tanks ran out of fuel and the pilot switched the fuel selector handles to the main tanks, which the fuel gauge indicated were a ¼-full. The pilot then decided to land and purchase fuel. When the airplane was on a four-mile final approach to the diversion airport, the left engine stopped producing power. About 30 seconds later, the right engine stopped producing power. The pilot was unable to maintain altitude and made a forced landing to a field. The airplane struck a hay bale, which resulted in substantial damage to the fuselage and wings. Postaccident examination of the airplane revealed six fuel tanks were intact and empty of fuel. A fuel line fitting to the right auxiliary tank was observed to be loose, stained blue/green, and most likely had been actively leaking fuel. The amount of fuel lost due to this leak could be not determined. The airplane was equipped with three fuel tanks (main, auxiliary and tip tank) in each wing, for a total of 120 gallons total (114 useable). Each tank was independent of each other, so the leak in the right auxiliary fuel tank would have only affected the fuel level in that tank. The pilot reported there was about 55 gallons of fuel onboard when he departed, and the airplane consumed an average of 15 gallons per hour. Based on this information, if the right auxiliary tank (15 gallons total) was empty due to the leak, there still should have been about 40 gallons of fuel onboard (or about 2.6 hours of fuel). The pilot said that he did not visually check the fuel quantity prior to flight because the airplane “…does not have a way to visually check the fuel and know how much fuel you have in the tanks.” However, the Pilot Operating Handbook states, that the pilot should visually check the fuel supply in each tank before flight. As such, even though the pilot thought he had sufficient fuel to complete his flight, postaccident examination of the airplane revealed the fuel tanks were not breached and empty of fuel. A loose fuel line fitting in the right auxiliary fuel tank likely contributed to some unquantifiable loss of fuel from that tank. Had the pilot used the preflight checklist, and visually looked in all six fuel tanks, he would have seen that there was insufficient fuel in all of the tanks to complete the flight. As a result, both engines lost total power due to fuel exhaustion 20 minutes after takeoff, which resulted in a forced landing to field.

Quoted verbatim from the NTSB record.