Team Rocket F-1 F-1 N230BW

Summary

On 24 December 2019 at about 19:15 local time, a Team Rocket F-1 F-1 registered N230BW was involved in an accident near Suffolk, Virginia, United States. 2 people were on board and nobody was injured. The aircraft was substantially damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

24 December 2019 at 19:15

Classification

Accident

Location

Suffolk, Virginia, United States

Coordinates

36.6397, -76.5234

Aircraft

Team Rocket F-1 F-1

Registration

N230BW

Category

Airplane

Year built

2009

Engines

1

Operator

Not recorded

Operating rule

Part 91: General Aviation

Purpose of flight

Personal

Phase of flight

Not recorded

Route

Suffolk → Norfolk

Aircraft damage

Substantial

Weather

VMC

Light

Day

NTSB number

ERA20LA080

Nobody was injured.

A structural failure of the horizontal stabilizer during aerobatic maneuvers near the airplane’s never-exceed speed. Contributing to the failure was the construction of the horizontal stabilizer that did not meet the kit manufacturer’s specifications.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

The pilot and pilot-rated passenger were performing aerobatic maneuvers in the experimental amateur-built airplane. After the pilot had performed several aileron rolls, barrel rolls, and wing overs, the pilot-rated passenger in the aft seat attempted to conduct a barrel roll. Data from onboard avionics indicated that, during the descending portion of the roll, the airplane reached a 9,166 ft-per-minute rate of descent at an airspeed of 238 knots, 2 knots below the airplane’s never-exceed speed (Vne). The pilots then heard a loud noise and felt a buffet in the aft flight controls, and reported limited pitch control movement. The airplane subsequently experienced a negative G-load and an decrease in pitch attitude. The pilot attempted to recover from this rapid descent, during which the airplane reached an airspeed of 240.5 knots and a +3.68g-load. The pilot was able to recover at 455 ft mean sea level and return to the airport and land. Postaccident examination of the airplane revealed that the right horizontal stabilizer forward of the aft spar was missing and the elevator assembly remained attached. The left horizontal stabilizer and associated elevator assembly was bent downward but remained attached and operable. The upper and lower straps on the forward spar only had four rivets each including the one at the closeout rib, but, according to kit manufacturer’s specifications, there should have been five rivets each. This likely lowered the structural integrity of the stabilizer and contributed to the structural failure but was likely not the primary cause. Although flutter was reported by both pilots and could not be ruled out, the damage to the horizontal stabilizer was consistent with its failure due to aerodynamic overload during aerobatic maneuvers near the airplane’s Vne.

Quoted verbatim from the NTSB record.