Swearingen SA227 TT N6UP

Summary

On 19 January 2018 at about 22:30 local time, a Swearingen SA227 TT registered N6UP, operated by Airco JN LLC, was involved in an accident near Houston, Texas, United States. 4 people were on board and nobody was injured. The aircraft was substantially damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

19 January 2018 at 22:30

Classification

Accident

Location

Houston, Texas, United States

Nearest airport

Ellington Airport (EFD)

Coordinates

29.6072, -95.1586

Aircraft

Swearingen SA227 TT

Registration

N6UP

Category

Airplane

Year built

1981

Engines

2

Operator

Airco JN LLC

Operating rule

Part 91: General Aviation

Purpose of flight

Executive/Corporate

Phase of flight

Not recorded

Route

Beaumont → Uvalde

Aircraft damage

Substantial

Weather

VMC

Light

Day

NTSB number

CEN18LA086

Nobody was injured.

The failure of the left starter relay during engine start, which resulted in a loss of electrical and battery power during the flight and led to a forced landing with the nose landing gear not fully extended, causing substantial damage to the engines.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

During a corporate flight, as the pilots climbed the airplane to flight level 180, both electrical generators failed and would not reset. The pilots attempted to troubleshoot the problem but could not regain electrical power. The airplane's battery power was rapidly deteriorating, so the pilots declared an emergency and diverted to the nearest airport. Due to the loss of electrical power, the pilots lost communications and had to manually extend the landing gear. They could not verify, with air traffic control tower personnel, if the landing and nose gear were extended and locked. The pilots made a forced landing with the nose landing gear not fully extended, causing the airplane to skid on the forward fuselage after touchdown and substantially damaging the engines. Postaccident examination of the airplane revealed the right generator current limiter had failed. A mechanic connected a battery to the airplane, and the left propeller immediately began to rotate. The mechanic determined that there was uncommanded voltage to the left starter, which was caused by a failure of the left starter relay when the engine was started before the flight. During the flight, the right generator was managing all of the airplane's electrical load, the cumulative electrical load exceeded the capacity of the right generator current limiter, and the generator failed. At that point, the airplane's electrical load was only being supplied by battery power, which was quickly depleted. Postaccident examination of the nose landing gear did not identify a mechanical reason to explain why the nose landing gear did not extend during the pilots' emergency landing gear extension procedure.

Quoted verbatim from the NTSB record.