Cessna 172 N5639A

Summary

On 25 January 2017 at about 23:30 local time, a Cessna 172 registered N5639A was involved in an accident near Jay, Oklahoma, United States. One person was on board and one died. The aircraft was substantially damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

25 January 2017 at 23:30

Classification

Accident

Location

Jay, Oklahoma, United States

Coordinates

36.5011, -94.8086

Aircraft

Cessna 172

Registration

N5639A

Category

Airplane

Year built

1956

Engines

1

Operator

Not recorded

Operating rule

Part 91: General Aviation

Purpose of flight

Personal

Phase of flight

Not recorded

Route

Jay → Grove

Aircraft damage

Substantial

Weather

VMC

Light

Day

NTSB number

CEN17FA085

1 person died.

The pilot's negligent maintenance of the airplane, which resulted in improper fuel management, fuel starvation, and a loss of engine power during takeoff due to a missing securing pin in the fuel selector handle, and a subsequent forced landing on unsuitable terrain.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

The private pilot was conducting a personal cross-country flight. Fuel records indicated that the pilot had purchased 9.56 gallons of fuel the day before the accident. A witness reported observing the pilot use fuel cans to add fuel to both airplane's fuel tanks. The witness saw the pilot taxi up and down the runway multiple times and subsequently depart; he then drove to the nearby airport (the pilot's intended destination) to pick up the pilot. When the pilot did not arrive, he reported the airplane missing. Responders tracked the emergency locator transmitter signal, and a helicopter pilot spotted the airplane in a field near a tree line. Upon examination, the propeller blades did not exhibit any chordwise abrasions or leading edge nicks, consistent with the engine not producing power at the time of impact. The fuel system was found intact except for a separated line near the left fuel tank. About 6 gallons of a blue-colored liquid consistent with the smell and color of aviation gasoline (avgas) was recovered from the right fuel tank. About 2 gallons of liquid consistent with avgas was recovered from the left fuel tank. Each fuel tank could hold 21 gallons of fuel, of which 2.5 gallons was unusable. There was some liquid consistent with avgas found in the carburetor bowl and in the firewall-mounted strainer bowl. All found and recovered liquid samples were tested for water contamination, and no water contamination was observed. Observed airplane damage was consistent with impact with trees and inverted impact with terrain. The fuel valve selector handle was found in the "right tank" position. However, no securing pin was installed in the selector handle, and during postaccident examination, pressurized air applied to the main fuel line at the firewall was observed discharging from the left tank's fuel line, which showed the selector valve fed the engine from the left tank. The engine operated normally during postaccident engine test runs. Based on the evidence, it is likely that the engine was starved of fuel when the fuel selector handle did not move the fuel selector valve to the desired position because the necessary securing pin was missing. The airplane's most recent annual inspection was completed about 8.5 years before the accident. The lack of routine maintenance on the airplane likely eliminated the necessary opportunities for the missing securing pin to be corrected.

Quoted verbatim from the NTSB record.