Airbus A300B4-605R N14056

Summary

On 20 November 2000 at about 17:22 local time, a Airbus A300B4-605R registered N14056, operated by American Airlines, was involved in an accident near Miami, Florida, United States. 133 people were on board and one died, 3 were seriously injured, 19 had minor injuries. The aircraft was slightly damaged. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

20 November 2000 at 17:22

Classification

Accident

Location

Miami, Florida, United States

Nearest airport

Miami International (KMIA)

Coordinates

25.8150, -80.2967

Aircraft

Airbus A300B4-605R

Registration

N14056

Category

Airplane

Engines

2

Operator

American Airlines

Operating rule

Part 121: Air Carrier

Phase of flight

Not recorded

Route

Miami → Port Au Prince

Aircraft damage

Minor

Weather

VMC

Light

Day

NTSB number

MIA01FA029

1 person died.

The failure of the flight crew to perform the cabin pressurization manual control abnormal checklist after experiencing a pressurization system malfunction and switching to manual pressurization control, and the failure of the flight crew to perform the emergency landing checklist prior to landing, resulting in the airplane having an excessive cabin pressure level after landing which led to a rapid decompression of the airplane when a flight attendant opened door and was ejected out of the airplane during emergency evacuation that was initiated by the captain. Contributing to the accident was the failure of operator maintenance personnel to ensure that insulation blankets around the forward and aft outflow valves were properly secured in accordance with airplane manufacturer's data, resulting in a malfunction of the pressurization system. Other contributing factors include the absence of FAA requirements that each emergency exit door has a system to relieve pressure or contain specific warnings (such as lights, placards, or other indications that clearly identify the danger of opening the emergency exit doors when the airplane is over pressurized); the absence of FAA technical specifications for lavatory ionization smoke detectors; the absence of a requirement in the airplane's ground/emergency evacuation checklist for the flight crew to ensure that the cabin differential pressure is zero pounds per square inch before signaling flight attendants to begin an emergency evacuation; and the absence of a mechanical stop in the negative direction on the cabin altimeter gauge.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

After takeoff from Miami, the flight experienced a pressurization system malfunction, which the captain identified as the airplane depressurizing. The flight attendants and passengers complained of pain in their ears at that time. The flight crew placed the pressurization system into manual control, turned off the autopilot and autothrottle systems, and began a descent to return to Miami. During the return to Miami, several lavatory smoke alarms activated and the captain call light illuminated in the cabin; however, no evidence of fire or smoke was found. The flight crew did not complete the checklists for manual pressurization control and emergency landing during the return to Miami, both of which called for the airplane to be depressurized prior to landing. After landing and stopping on a taxiway, the captain also noticed an aft baggage compartment fire loop light illuminated, prompting him to evacuate the airplane. After the captain ordered the evacuation, the flight attendants attempted to open the doors. The doors would not open. The flight attendant/purser at the L1 (front left passenger) door continued to attempt to open the door, and the door explosively opened, ejecting the flight attendant/purser from the airplane to the ground, causing fatal injuries. The remainder of the doors opened and the airplane was evacuated. The emergency evacuation checklist did not call for the flight crew to check for depressurization of the airplane prior to commanding an evacuation. Post-accident examination of the airplane revealed that insulation blankets, which had been manufactured and replaced by the airplane operator's maintenance personnel, had not been properly secured per the airplane manufacturer's data. The blanket had migrated over to, and partially blocked, the forward and aft pressurization outflow valves, leading to the pressurization system malfunction. The forward outflow valve was found 3/8-open and the aft outflow valve was found fully closed. The lavatory smoke alarms were found to activate when subjected to abnormal pressure. There were no FAA technical standards for the lavatory smoke detectors. A sensor in the aft cargo compartment was found out of tolerance and also activated when subjected to abnormal pressure. The cabin doors were found to have no means for relieving pressure prior to opening the doors. The cabin altimeter in the cockpit did not have a mechanical stop in the negative direction, and under excessive pressure conditions, allowed the needle to move past the negative range into the high positive range. The aircraft manufacturer stated that when the pressurization system is in the manual mode, the outflow valves do not automatically open during landing and that a person cannot open a door if the airplane is pressurized above approximately 1.5 psi differential. As result of this investigation, the Safety Board previously issued 18 safety recommendations to the FAA.

Quoted verbatim from the NTSB record.