Bombardier CL-600-2B19 N729CA

Summary

On 26 December 2000 at about 22:29 local time, a Bombardier CL-600-2B19 registered N729CA, operated by Comair Inc, was involved in an incident near Hebron, Kentucky, United States. 53 people were on board and nobody was injured. The NTSB has published a probable cause for this accident; it is quoted in full below.

Date

26 December 2000 at 22:29

Classification

Incident

Location

Hebron, Kentucky, United States

Coordinates

39.0802, -84.6999

Aircraft

Bombardier CL-600-2B19

Registration

N729CA

Category

Airplane

Engines

2

Operator

Comair Inc

Operating rule

Part 121: Air Carrier

Phase of flight

Not recorded

Route

Hebron → Greer

Aircraft damage

Not recorded

Weather

VMC

Light

Not Reported

NTSB number

MIA01IA051

Nobody was injured.

The inadequate design of the flight compartment windshield by the windshield manufacturer resulting in cracking of the center ply.

Quoted verbatim from the NTSB record. This site does not paraphrase or interpret it.

Read the full NTSB narrative

While climbing through 20,000 feet in visual meteorological conditions, the captain's windshield "shattered." The captain did not declare an emergency; the flight returned to the departure airport and landed uneventfully. The damaged windshield (PPG part number NP 139321-5, S/N 99018H7134) was removed from the airplane and initial examination revealed that the center ply was failed. The window was further examined in the presence of representatives of the NTSB, FAA, Bombardier, and PPG, at one PPG's facilities. A report of the damaged windshield prepared by PPG indicates, "The fracture originated 0.20 inch from the bottom edge and 3.8 inches from the center of the forward corner. The origin of the fracture was a peel chip that developed on the outboard surface in the bottom forward corner area. The initiation point of the peel chip damage was located 0.115 inch from the inner edge of the Teflon tape and 0.325 inch from the glass edge." The report also indicates that examination of the peel chip using a microscope, "...did not reveal any surface damage at the peel chip initiation point, nor was there any indication of manufacturing defects." No discrepancies were noted with the anti-ice heating system and sensing elements. Optical distortion check of the damaged window was performed which revealed, "There was no slope-line distortion apparent in the critical vision area. However, facilities were not available to perform a quantitative distortion evaluation." Residual visibility examination could not be performed due to the absence of a standard and prescribed method of evaluation. Manufacturing of windshield S/N 99018H7134 was completed on January 18, 1999; the window was installed in the incident airplane by Comair maintenance personnel on March 27, 1999, to replace the previous window which "shattered while sitting at gate power off." The incident window had accumulated a reported 4,422.8 hours and 4,526 cycles at the time of failure.

Quoted verbatim from the NTSB record.